Thanks: 0
Hello
A week ago i noticed that the Horn on my 750x started to sound strange. Dumb me, i thought it was caused by the rain that fell that week. 2 days ago the bike didn't start due to low battery.
Yesterday I took the battery out and charged it.after full charge and 1 hour, with a multimeter, i measured 12.72v... bike started ok and this morning the battery had 12.7, 12.68v. So i guess its good.
When idleing i measure 12.5ish V and if i increase the rpm to 3000/3500 i starts to go up, slowly. 30seg at Those Rpm and it reaches 12.8/ 13.0v... i guess it continues to rise but seems too slow, doesn't it? Shouldn't be higher when idleing?
Does this seems fine to you? What are your measures?
I bought the bike new, made 1 year this month. Has 22000km. I have h4 led headlight bulb, 2 10w led auxiliary Lights, frunk 12v socket and Garmin GPS charger, all connected to the acc harness. I use it daily to go to work, 25km.
Enviado do meu ASUS_Z00ED através de Tapatalk
I think that's low. Honda says the battery should be 13 to 13.2 volts fully charged. If your battery is bad it's hard to check your bike's charging system but my feeling is running voltage should be above 13 volts at idle with a good battery. I'll try to get some measurements on my 750 today.
Last edited by HarveyM; 27th October 2016 at 06:04.
You should have 14-14.5 V +/- charging voltage from alternator almost all the time when engine is running.
Your charger/maintainer should be able to give about 13.8 V charging voltage.
Battery should be charged ones every 2-3 weeks for minimum 6-8 hours.
The more you ride, the longer the battery will last. If the bike sits, the battery will give you fits.
Why not seize the pleasure at once? -- How often is happiness destroyed by preparation, and foolish planning? Just do it. Shut the frunk up and Ride !!!!!!!!!!
At idle my charging system puts out about 14V. Yours does seem low. My commute to work is 12 miles each way so once a week i put it on a charger overnight due to the fact that rides of that short distance might not recharge the battery to full after taking out the charge of starting the bike. Kind of like taking a sip of water from a glass every day but only putting back in a half a sip. Eventually you will run out of water in the glass.
I just checked mine. The battery was at 12.7 volts. At idle the voltage was 14.4 volts. This is on a 3 month old 750 DCT.
Good luck with yours!
Battery's condition affects the readings of the charging system. So we can talk only about the battery.
(That's why any test of the charging system need a fresh new battery and 5000 rpm [generator's max. output])
Your battery seems to able to keep about 70% of its named capacity. Not bad.
It's always a good idea to monitor the battery and the charging system to avoid any (bad) surprises...
Take a look at Yuasa's Technical Manual to have an idea about AGM batteries...
It's 13.0V for Yuasa, Varta & other (always refer to the manufacturers instructions), when they're new / fresh.Originally Posted by HarveyM
As the battery deteriorates this number will be lower, and lower... At 12.5V and lower you must consider to replace it because there is not enough juice to start he engine at a cold night...
With a healthy charging system we must always see a charging voltage > battery's voltage.
The ideal charging voltage for an AGM is 14.4V
Problem solved (i guess)
Today tried to look out what was going wrong. Took off the front sprocket cover and look at the cables and there was a cable with 3 yellow wires inside that was touching the Chain. Then i Isolate the wires, checked the voltage at idle and was higher than 14v 😁
Enviado do meu ASUS_Z00ED através de Tapatalk
It's hard to imagine how this happened. Any wires are pretty far from chain.
And there supposed to be curved chain guard... Did you lose it?
Attachment 31662
Last edited by lootzyan; 28th October 2016 at 11:13.
Posting Permissions
Likes: 
Reply With Quote